BODYSHELL & GROMMETS - TR5 - TR250 - Your Shop for British Classic Ca

CAR IDENTIFICATION TR5 - TR6

Before ordering any parts for your TR sports car, it is essential that you have full details of the chassis number, engine number, body number, rear axle and gearbox numbers.

Number Locations

Commission/Chassis Number	The commission number on TR5-250 and early TR6 models were mounted on plates affixed to the top of the inner lefthand front wing. The plate included the commission number which could have a suffix 'L' or 'U' (1971 on) for lefthand drive models, and 'O' for overdrive. Paint & trim colour codes were also shown.
	Later TR6 models had the commission plate attached to the lefthand 'B' post, below the door shut plate.
Body Number	Two plates attached to the bulkhead were body numbers. One was fitted by the manufacturers of the body shell, the other by Triumph. These numbers are not required when ordering replacement parts.
Engine Number	The engine number was stamped onto a lip at the rear of the lefthand side of all engine blocks, just visible below the spark plug. The engine number is essential when ordering engine parts.
Gearbox Number	The gearbox number is stamped onto the casing just behind the clutch lever cross- haft box. On later US models the number was stamped above the starter motor bulge on the righthand side of the gearbox casing. Use this number when ordering gearbox parts.
Rear Axle Number	The rear axle number is located at the base of the axle housing, when viewed from beneath the car. Use this number when ordering axle parts.

TR5 Pi Models
1967	CP1	Prototype
	CP2	First production car, (built 29th August 1967)
	CP585	Last production car that year
1968	CP586	First production car, (built 1st January 1968)
	CP3101	Last production car, (built 19th September 1968)

TR250 Carburettor Models
1967	CD1-L	First production car, (built on 11th July 1967)
	CD2684 L	Last production car that year
1968	CD2685 L	First production car
	CD8594 L	Last production car, (built 19th September 1968)

TR6 Pi Models
1968	1969 model year
	CP25156	First production car, (built 28th November 1968)
	CP25158	Last production car that year
	CP25001	First car was probably a prototype
	CKD	CP25002 To CP25145 were CKD
1969	1969 model year
	CP25159	First production car, (built 2nd January 1969)
	CP26998	Last production car, (built 10th September 1968)
	1970 model year
	CP50001	First production car, (built 1st September 1969)
	CP50464	Last production car that year
	CKD	CP50002 To CP50436 believed to be CKD
1970	1970 model year
	CP50465	First production car, (built 1st January 1970)
	CP52785	Last production car that year
1971	1971 model year
	CP52786	First production car, (built 1st January 1971)
	CP54572	Last production car, (built 7th September 1971)
	CKD	CP54573 To CP54584 were CKD cars
	1972 model year
	CP75001	First production car, (built 27th September 1971)
	CP7544	Last production car that year
1972	1972 model year
	CP75455	First production car, (built 3rd January 1972)
	CP77718	Last production car, (built 21st September 1972)
	1973 model year
	CR169	First production car, (built 15th November 1972)
	CR664	Last production car that year
	CKD	CR1 to CR168 were CKD cars
1973	1973 model year
	CR665	First production car, (built on 2nd January 1973)
	CR2911	Last production car, (built 17th October 1973)
	1974 model year
	CR5049	First production car, (built 14th September 1973)
	CR5612	Last production car that year
	CKD	CR5001 To CR5048 were CKD cars
1974	1974 model year
	CR5613	First production car, (built 1st January 1974)
	CR6630	Last production car that year
1975	1974 model year
	CR6631	First production car, (built 1st January 1975)
	CR6701	Last production car, (built 7th February 1975)

TR6 Carburettor Models
1968	1969 model year
	CC25003 L	First production car, (built 19th September 1968)
	CC27383 L	Last production car that year
	CC25001 & CC25002	Not yet found in factory build records
1969	1969 model year
	CC27384 L	First production car, (built 2nd January 1969)
	CC32142 L	Last production car, (built 19th December 1969)
	1970 model year
	CC50001 L	First production car, (built 22nd November 1969)
	CC51032 L	Last production car that year
1970	1970 model year
	CC51033 L	First production car, (built 1st January 1970)
	CC60902 L	Last production car that year
1971	1971 model year
	CC60903 L	First production car, (built 1st January 1971)
	CC67893 L	Last production car, (built 20th August 1971)
	1972 model year
	CC75001 L	First production car, (built 20th August 1971)
	CC7881	Last production car that year
1972	1972 model year
	CC78813 U	First production car, (built 3rd January 1972)
	CC85737 U	Last production car, (built 5th October 1972)
	1973 model year
	CF1 U	First production car, (built 11th September 1972)
	CF 4028 U	Last production car that year
1973	1973 model year
	CF4029 U	First production car, (built 2nd January 1973)
	CF17002 U	Last production car that year
1974	1974 model year
	CF17002 U	First production car, (built 2nd January 1974)
	CF25777 U	Last production car, (built 18th September 1974)
	1975 model year
	CF27001 U	First production car, (built 22nd August 1974)
	CF29580 U	Last production car that year
1975	1975 model year
	CF29581 U	First production car, (built 2nd January 1975)
	CF39991 U	Last production car, (built 23rd August 1975)
	1976 model year
	CF50001 U	First production car, (built 29th August 1975)
	CF52314 U	Last production car that year
1976	1976 model year
	CF52315 U	First production car, (built 5th January 1976)
	CF58328 U	Last production TR6, (built 15th July 1976)

BODYSHELL & GROMMETS - TR5 - TR250

Ill.no.	Partno.	Part	Quantity required	Info	Price
1	574351	BODYSHELL TR5 RHS NCA BUT POA	1	TR5	availability request (add quantity to basket, offer follows)
1	574352	BODYSHELL TR5/250 LHS NCA BUT POA	1	TR5, TR250	availability request (add quantity to basket, offer follows)
1	SF250	TRANSPORTATION FRAME, BODYSHELL	1		availability request (add quantity to basket, offer follows)

Ill.no.	Partno.	Part	Quantity required	Info	Price
2	574244	BODY MOUNTING KIT	1		CHF 163.35

Ill.no.	Partno.	Part	Quantity required	Info	Price
3	TGK154	GROMMET & PLUG KIT, COMPLETE	1		CHF 97.30

Ill.no.	Partno.	Part	Quantity required	Info	Price
4	TGK155	GROMMET & PLUG KIT, FRONT	1	bulkhead and forward	CHF 35.25

Ill.no.	Partno.	Part	Quantity required	Info	Price
5	610608	STEERING COLUMN GROMMET	1	fits 2 3/8" hole - steering column, through bulkhead	CHF 13.25

Ill.no.	Partno.	Part	Quantity required	Info	Price
6	600400W	GROMMET, RUBBER 1 1/2"OD X 3/4"ID	1	fits 1 1/2" hole - main wiring loom, through bulkhead, driver's side	CHF 3.25

Ill.no.	Partno.	Part	Quantity required	Info	Price
7	600395	GROMMET, RUBBER, 1"OD X 1/8"ID	1	fits 1 1/4" hole - wiper rack tube, through bulkhead	CHF 2.10

Ill.no.	Partno.	Part	Quantity required	Info	Price
8	602037	GROMMET, RUBBER, 1"OD X 1/4"ID	1	fits 1" hole - main wiring loom, through bulkhead, passenger's side	CHF 3.40

Ill.no.	Partno.	Part	Quantity required	Info	Price
9	602037	GROMMET, RUBBER, 1"OD X 1/4"ID	1	fits 1" hole - speedometer and tachometer cables	CHF 3.40

Ill.no.	Partno.	Part	Quantity required	Info	Price
10	600399	GROMMET, RUBBER, 1" OD	1	fits 1" hole - blanking hole on bulkhead for speedometer cable routing	CHF 2.50

Ill.no.	Partno.	Part	Quantity required	Info	Price
11	602037	GROMMET, RUBBER, 1"OD X 1/4"ID	1	fits 1" hole - through bulkhead end panel	CHF 3.40

Ill.no.	Partno.	Part	Quantity required	Info	Price
12	061917	GROMMET, RUBBER, 1/2" OD X 1/8" ID	2	fits 1/2" hole - marker and side lamp cables through inner wing	CHF 1.70

Ill.no.	Partno.	Part	Quantity required	Info	Price
13	600395	GROMMET, RUBBER, 1"OD X 1/8"ID	1	fits 1" hole - oil pressure gauge tube through bulkhead	CHF 2.10

Ill.no.	Partno.	Part	Quantity required	Info	Price
14	602037	GROMMET, RUBBER, 1"OD X 1/4"ID	1	fits 1" hole - choke cable and water valve control cable through bulkhead	CHF 3.40

Ill.no.	Partno.	Part	Quantity required	Info	Price
15	061917	GROMMET, RUBBER, 1/2" OD X 1/8" ID	1	fits 1/2" hole - bonnet release cable through bulkhead	CHF 1.70

Ill.no.	Partno.	Part	Quantity required	Info	Price
16	061917	GROMMET, RUBBER, 1/2" OD X 1/8" ID	1	fits 1/2" hole - screen washer electrical cable through bulkhead	CHF 1.70

Ill.no.	Partno.	Part	Quantity required	Info	Price
17	061917	GROMMET, RUBBER, 1/2" OD X 1/8" ID	2	fits 1/2" hole - screen washer tubing through bulkhead and into plenum	CHF 1.70

Ill.no.	Partno.	Part	Quantity required	Info	Price
18	061917	GROMMET, RUBBER, 1/2" OD X 1/8" ID	2	fits 1/2" hole - scuttle vent operating rod into plenum	CHF 1.70

Ill.no.	Partno.	Part	Quantity required	Info	Price
19	611040	GASKET, HEATER CONNECTOR, BULKHEAD	1		CHF 3.40

Ill.no.	Partno.	Part	Quantity required	Info	Price
20	CD27769	PLUG RUBBER, OIL FILTER WARNING LIGHT	1	fits 3/8" hole - blanking holes in bulkhead adjacent to screen washer reservoir	CHF 4.15

Ill.no.	Partno.	Part	Quantity required	Info	Price
21	TGK156	GROMMET & PLUG KIT, COCKPIT	1	cockpit area	CHF 31.60

Ill.no.	Partno.	Part	Quantity required	Info	Price
22	603384	GROMMET, RUBBER	2	fits 3 1/4" hole - blanking jacking hole in floor panels	CHF 4.75

Ill.no.	Partno.	Part	Quantity required	Info	Price
23	CFP625	GROMMET 5/8IN DIA	2	fits 5/8" hole - blanking holes in floor panel behind seat	CHF 1.40

Ill.no.	Partno.	Part	Quantity required	Info	Price
24	600399	GROMMET, RUBBER, 1" OD	2	fits 1" hole - blanking holes in floor panel behind seat	CHF 2.50

Ill.no.	Partno.	Part	Quantity required	Info	Price
25	602037	GROMMET, RUBBER, 1"OD X 1/4"ID	2	fits 1" hole - handbrake cable through heel board	CHF 3.40

Ill.no.	Partno.	Part	Quantity required	Info	Price
26	602037	GROMMET, RUBBER, 1"OD X 1/4"ID	1	fits 1" hole - gearbox wiring loom through gearbox tunnel cover	CHF 3.40

Ill.no.	Partno.	Part	Quantity required	Info	Price
27	605602	PLUG 2.5"	1	fits 2 1/2" hole - prop shaft lubrication access	CHF 11.25

Ill.no.	Partno.	Part	Quantity required	Info	Price
28	GHF822	GROMMET BUNG 3/8 X 1/16	2	fits 3/8" hole - blanking, screen capping	CHF 1.05

Ill.no.	Partno.	Part	Quantity required	Info	Price
29	TGK157	GROMMET & PLUG KIT, BOOT	1	boot area and rear of bulkhead trim panel	CHF 55.40

Ill.no.	Partno.	Part	Quantity required	Info	Price
30	GHF822	GROMMET BUNG 3/8 X 1/16	1	fits 3/8" hole - chassis rear crossmember	CHF 1.05

Ill.no.	Partno.	Part	Quantity required	Info	Price
31	611733	SEALING WASHER, SPONGE, 15.7MM ID	2	when drain plug in tank	CHF 5.40

Ill.no.	Partno.	Part	Quantity required	Info	Price
32	623176	PLUG RUBBER BLANKING 1.375 HOLE	1	fits 1 3/8", hole when no drain plug in tank	CHF 3.05

Ill.no.	Partno.	Part	Quantity required	Info	Price
33	600399	GROMMET, RUBBER, 1" OD	2	fits 1" hole, TR250 only - blanking holes either side of petrol tank	CHF 2.50

Ill.no.	Partno.	Part	Quantity required	Info	Price
34	ADA803	GROMMET 5/16 RAISED	3	fits 1/4" hole, TR250 only - arch side blanking, redundant Pi pump mounts	CHF 3.60

Ill.no.	Partno.	Part	Quantity required	Info	Price
35	600399	GROMMET, RUBBER, 1" OD	1	fits 1" hole	CHF 2.50

Ill.no.	Partno.	Part	Quantity required	Info	Price
36	600395	GROMMET, RUBBER, 1"OD X 1/8"ID	1/2	fits 1" hole, qty. increases on TR5	CHF 2.10

Ill.no.	Partno.	Part	Quantity required	Info	Price
37	600399	GROMMET, RUBBER, 1" OD	1	fits 1" hole, TR250 only - blanking fuel pipe holes through boot floor	CHF 2.50

Ill.no.	Partno.	Part	Quantity required	Info	Price
38	602037	GROMMET, RUBBER, 1"OD X 1/4"ID	1	fits 1" hole, TR5 only - petrol pump vent pipe through boot floor	CHF 3.40

Ill.no.	Partno.	Part	Quantity required	Info	Price
39	600397	GROMMET	1	fits 1" hole, TR5 only - fuel hose, petrol pump to PRV through boot floor	availability request (add quantity to basket, offer follows)

Ill.no.	Partno.	Part	Quantity required	Info	Price
40	600395	GROMMET, RUBBER, 1"OD X 1/8"ID	1	fits 1 1/4" hole, TR5 only - fuel hose, PRV to filter through seat pan	CHF 2.10

Ill.no.	Partno.	Part	Quantity required	Info	Price
41	RFR208	PLUG, RUBBER 1/2 DIA X 1/16	4	fits 1/2" hole, as fitted	availability request (add quantity to basket, offer follows)

Ill.no.	Partno.	Part	Quantity required	Info	Price
42	600395	GROMMET, RUBBER, 1"OD X 1/8"ID	2	fits 1" hole, TR5 except Germany, TR250	CHF 2.10
42	061917	GROMMET, RUBBER, 1/2" OD X 1/8" ID	2	fits 1/2" hole, TR5 German markets	CHF 1.70

Ill.no.	Partno.	Part	Quantity required	Info	Price
43	600395	GROMMET, RUBBER, 1"OD X 1/8"ID	1	fits 1" hole - reverse lamp and side marker cables through rear body side	CHF 2.10

Ill.no.	Partno.	Part	Quantity required	Info	Price
44	600399	GROMMET, RUBBER, 1" OD	2	fits 1" hole, TR5 German markets	CHF 2.50

Ill.no.	Partno.	Part	Quantity required	Info	Price
45	650247	GROMMET FILLER CAP, RUBBER	1	fits 2 3/8" hole, TR5 only - petrol filler cap through rear deck	CHF 5.90
45	622683	TANK NECK GROMMET	1	fits 2 3/8" diameter hole, TR250 only	availability request (add quantity to basket, offer follows)

Ill.no.	Partno.	Part	Quantity required	Info	Price
46	RFR103	GROMMET, RUBBER, 3/16" ID	a/r	fits 5/16" diameter hole	CHF 7.05

Ill.no.	Partno.	Part	Quantity required	Info	Price
1	574351	BODYSHELL TR5 RHS NCA BUT POA	1	TR5	availability request (add quantity to basket, offer follows)
1	574352	BODYSHELL TR5/250 LHS NCA BUT POA	1	TR5, TR250	availability request (add quantity to basket, offer follows)
1	SF250	TRANSPORTATION FRAME, BODYSHELL	1		availability request (add quantity to basket, offer follows)
2	574244	BODY MOUNTING KIT	1		CHF 163.35
3	TGK154	GROMMET & PLUG KIT, COMPLETE	1		CHF 97.30
4	TGK155	GROMMET & PLUG KIT, FRONT	1	bulkhead and forward	CHF 35.25
5	610608	STEERING COLUMN GROMMET	1	fits 2 3/8" hole - steering column, through bulkhead	CHF 13.25
6	600400W	GROMMET, RUBBER 1 1/2"OD X 3/4"ID	1	fits 1 1/2" hole - main wiring loom, through bulkhead, driver's side	CHF 3.25
7	600395	GROMMET, RUBBER, 1"OD X 1/8"ID	1	fits 1 1/4" hole - wiper rack tube, through bulkhead	CHF 2.10
8	602037	GROMMET, RUBBER, 1"OD X 1/4"ID	1	fits 1" hole - main wiring loom, through bulkhead, passenger's side	CHF 3.40
9	602037	GROMMET, RUBBER, 1"OD X 1/4"ID	1	fits 1" hole - speedometer and tachometer cables	CHF 3.40
10	600399	GROMMET, RUBBER, 1" OD	1	fits 1" hole - blanking hole on bulkhead for speedometer cable routing	CHF 2.50
11	602037	GROMMET, RUBBER, 1"OD X 1/4"ID	1	fits 1" hole - through bulkhead end panel	CHF 3.40
12	061917	GROMMET, RUBBER, 1/2" OD X 1/8" ID	2	fits 1/2" hole - marker and side lamp cables through inner wing	CHF 1.70
13	600395	GROMMET, RUBBER, 1"OD X 1/8"ID	1	fits 1" hole - oil pressure gauge tube through bulkhead	CHF 2.10
14	602037	GROMMET, RUBBER, 1"OD X 1/4"ID	1	fits 1" hole - choke cable and water valve control cable through bulkhead	CHF 3.40
15	061917	GROMMET, RUBBER, 1/2" OD X 1/8" ID	1	fits 1/2" hole - bonnet release cable through bulkhead	CHF 1.70
16	061917	GROMMET, RUBBER, 1/2" OD X 1/8" ID	1	fits 1/2" hole - screen washer electrical cable through bulkhead	CHF 1.70
17	061917	GROMMET, RUBBER, 1/2" OD X 1/8" ID	2	fits 1/2" hole - screen washer tubing through bulkhead and into plenum	CHF 1.70
18	061917	GROMMET, RUBBER, 1/2" OD X 1/8" ID	2	fits 1/2" hole - scuttle vent operating rod into plenum	CHF 1.70
19	611040	GASKET, HEATER CONNECTOR, BULKHEAD	1		CHF 3.40
20	CD27769	PLUG RUBBER, OIL FILTER WARNING LIGHT	1	fits 3/8" hole - blanking holes in bulkhead adjacent to screen washer reservoir	CHF 4.15
21	TGK156	GROMMET & PLUG KIT, COCKPIT	1	cockpit area	CHF 31.60
22	603384	GROMMET, RUBBER	2	fits 3 1/4" hole - blanking jacking hole in floor panels	CHF 4.75
23	CFP625	GROMMET 5/8IN DIA	2	fits 5/8" hole - blanking holes in floor panel behind seat	CHF 1.40
24	600399	GROMMET, RUBBER, 1" OD	2	fits 1" hole - blanking holes in floor panel behind seat	CHF 2.50
25	602037	GROMMET, RUBBER, 1"OD X 1/4"ID	2	fits 1" hole - handbrake cable through heel board	CHF 3.40
26	602037	GROMMET, RUBBER, 1"OD X 1/4"ID	1	fits 1" hole - gearbox wiring loom through gearbox tunnel cover	CHF 3.40
27	605602	PLUG 2.5"	1	fits 2 1/2" hole - prop shaft lubrication access	CHF 11.25
28	GHF822	GROMMET BUNG 3/8 X 1/16	2	fits 3/8" hole - blanking, screen capping	CHF 1.05
29	TGK157	GROMMET & PLUG KIT, BOOT	1	boot area and rear of bulkhead trim panel	CHF 55.40
30	GHF822	GROMMET BUNG 3/8 X 1/16	1	fits 3/8" hole - chassis rear crossmember	CHF 1.05
31	611733	SEALING WASHER, SPONGE, 15.7MM ID	2	when drain plug in tank	CHF 5.40
32	623176	PLUG RUBBER BLANKING 1.375 HOLE	1	fits 1 3/8", hole when no drain plug in tank	CHF 3.05
33	600399	GROMMET, RUBBER, 1" OD	2	fits 1" hole, TR250 only - blanking holes either side of petrol tank	CHF 2.50
34	ADA803	GROMMET 5/16 RAISED	3	fits 1/4" hole, TR250 only - arch side blanking, redundant Pi pump mounts	CHF 3.60
35	600399	GROMMET, RUBBER, 1" OD	1	fits 1" hole	CHF 2.50
36	600395	GROMMET, RUBBER, 1"OD X 1/8"ID	1/2	fits 1" hole, qty. increases on TR5	CHF 2.10
37	600399	GROMMET, RUBBER, 1" OD	1	fits 1" hole, TR250 only - blanking fuel pipe holes through boot floor	CHF 2.50
38	602037	GROMMET, RUBBER, 1"OD X 1/4"ID	1	fits 1" hole, TR5 only - petrol pump vent pipe through boot floor	CHF 3.40
39	600397	GROMMET	1	fits 1" hole, TR5 only - fuel hose, petrol pump to PRV through boot floor	availability request (add quantity to basket, offer follows)
40	600395	GROMMET, RUBBER, 1"OD X 1/8"ID	1	fits 1 1/4" hole, TR5 only - fuel hose, PRV to filter through seat pan	CHF 2.10
41	RFR208	PLUG, RUBBER 1/2 DIA X 1/16	4	fits 1/2" hole, as fitted	availability request (add quantity to basket, offer follows)
42	600395	GROMMET, RUBBER, 1"OD X 1/8"ID	2	fits 1" hole, TR5 except Germany, TR250	CHF 2.10
42	061917	GROMMET, RUBBER, 1/2" OD X 1/8" ID	2	fits 1/2" hole, TR5 German markets	CHF 1.70
43	600395	GROMMET, RUBBER, 1"OD X 1/8"ID	1	fits 1" hole - reverse lamp and side marker cables through rear body side	CHF 2.10
44	600399	GROMMET, RUBBER, 1" OD	2	fits 1" hole, TR5 German markets	CHF 2.50
45	650247	GROMMET FILLER CAP, RUBBER	1	fits 2 3/8" hole, TR5 only - petrol filler cap through rear deck	CHF 5.90
45	622683	TANK NECK GROMMET	1	fits 2 3/8" diameter hole, TR250 only	availability request (add quantity to basket, offer follows)
46	RFR103	GROMMET, RUBBER, 3/16" ID	a/r	fits 5/16" diameter hole	CHF 7.05