HORNS, HORN RELAYS & FITTINGS

CAR IDENTIFICATION TR5 - TR6

Before ordering any parts for your TR sports car, it is essential that you have full details of the chassis number, engine number, body number, rear axle and gearbox numbers.

Number Locations

Commission/Chassis Number	The commission number on TR5-250 and early TR6 models were mounted on plates affixed to the top of the inner lefthand front wing. The plate included the commission number which could have a suffix 'L' or 'U' (1971 on) for lefthand drive models, and 'O' for overdrive. Paint & trim colour codes were also shown.
	Later TR6 models had the commission plate attached to the lefthand 'B' post, below the door shut plate.
Body Number	Two plates attached to the bulkhead were body numbers. One was fitted by the manufacturers of the body shell, the other by Triumph. These numbers are not required when ordering replacement parts.
Engine Number	The engine number was stamped onto a lip at the rear of the lefthand side of all engine blocks, just visible below the spark plug. The engine number is essential when ordering engine parts.
Gearbox Number	The gearbox number is stamped onto the casing just behind the clutch lever cross- haft box. On later US models the number was stamped above the starter motor bulge on the righthand side of the gearbox casing. Use this number when ordering gearbox parts.
Rear Axle Number	The rear axle number is located at the base of the axle housing, when viewed from beneath the car. Use this number when ordering axle parts.

TR5 Pi Models
1967	CP1	Prototype
	CP2	First production car, (built 29th August 1967)
	CP585	Last production car that year
1968	CP586	First production car, (built 1st January 1968)
	CP3101	Last production car, (built 19th September 1968)

TR250 Carburettor Models
1967	CD1-L	First production car, (built on 11th July 1967)
	CD2684 L	Last production car that year
1968	CD2685 L	First production car
	CD8594 L	Last production car, (built 19th September 1968)

TR6 Pi Models
1968	1969 model year
	CP25156	First production car, (built 28th November 1968)
	CP25158	Last production car that year
	CP25001	First car was probably a prototype
	CKD	CP25002 To CP25145 were CKD
1969	1969 model year
	CP25159	First production car, (built 2nd January 1969)
	CP26998	Last production car, (built 10th September 1968)
	1970 model year
	CP50001	First production car, (built 1st September 1969)
	CP50464	Last production car that year
	CKD	CP50002 To CP50436 believed to be CKD
1970	1970 model year
	CP50465	First production car, (built 1st January 1970)
	CP52785	Last production car that year
1971	1971 model year
	CP52786	First production car, (built 1st January 1971)
	CP54572	Last production car, (built 7th September 1971)
	CKD	CP54573 To CP54584 were CKD cars
	1972 model year
	CP75001	First production car, (built 27th September 1971)
	CP7544	Last production car that year
1972	1972 model year
	CP75455	First production car, (built 3rd January 1972)
	CP77718	Last production car, (built 21st September 1972)
	1973 model year
	CR169	First production car, (built 15th November 1972)
	CR664	Last production car that year
	CKD	CR1 to CR168 were CKD cars
1973	1973 model year
	CR665	First production car, (built on 2nd January 1973)
	CR2911	Last production car, (built 17th October 1973)
	1974 model year
	CR5049	First production car, (built 14th September 1973)
	CR5612	Last production car that year
	CKD	CR5001 To CR5048 were CKD cars
1974	1974 model year
	CR5613	First production car, (built 1st January 1974)
	CR6630	Last production car that year
1975	1974 model year
	CR6631	First production car, (built 1st January 1975)
	CR6701	Last production car, (built 7th February 1975)

TR6 Carburettor Models
1968	1969 model year
	CC25003 L	First production car, (built 19th September 1968)
	CC27383 L	Last production car that year
	CC25001 & CC25002	Not yet found in factory build records
1969	1969 model year
	CC27384 L	First production car, (built 2nd January 1969)
	CC32142 L	Last production car, (built 19th December 1969)
	1970 model year
	CC50001 L	First production car, (built 22nd November 1969)
	CC51032 L	Last production car that year
1970	1970 model year
	CC51033 L	First production car, (built 1st January 1970)
	CC60902 L	Last production car that year
1971	1971 model year
	CC60903 L	First production car, (built 1st January 1971)
	CC67893 L	Last production car, (built 20th August 1971)
	1972 model year
	CC75001 L	First production car, (built 20th August 1971)
	CC7881	Last production car that year
1972	1972 model year
	CC78813 U	First production car, (built 3rd January 1972)
	CC85737 U	Last production car, (built 5th October 1972)
	1973 model year
	CF1 U	First production car, (built 11th September 1972)
	CF 4028 U	Last production car that year
1973	1973 model year
	CF4029 U	First production car, (built 2nd January 1973)
	CF17002 U	Last production car that year
1974	1974 model year
	CF17002 U	First production car, (built 2nd January 1974)
	CF25777 U	Last production car, (built 18th September 1974)
	1975 model year
	CF27001 U	First production car, (built 22nd August 1974)
	CF29580 U	Last production car that year
1975	1975 model year
	CF29581 U	First production car, (built 2nd January 1975)
	CF39991 U	Last production car, (built 23rd August 1975)
	1976 model year
	CF50001 U	First production car, (built 29th August 1975)
	CF52314 U	Last production car that year
1976	1976 model year
	CF52315 U	First production car, (built 5th January 1976)
	CF58328 U	Last production TR6, (built 15th July 1976)

Ill.no.	Partno.	Part	Quantity required	Info	Price

See also Category STEERING WHEELS
1	150277	HORN CONTACT WITH TRIUMPH EMBLEM	1	TR5, TR250, TR6 To CR1/CF1	CHF 71.50

Ill.no.	Partno.	Part	Quantity required	Info	Price

See also Category STEERING WHEELS
2	159761	HORN PUSH ASSEMBLY, STEERING WHEEL, TRIUMPH WORD	1	TR6 From CR1/CF1	CHF 58.10

Ill.no.	Partno.	Part	Quantity required	Info	Price
3	204741	CLAMP SPRING HORN CONTACT BUTTON (3-ARM)	1	TR5, TR250, TR6 To CR1/CF1	CHF 31.00

Ill.no.	Partno.	Part	Quantity required	Info	Price
4	613766	CLIP, WOVEN DOOR SEAL	1	TR6 From CR1/CF1	CHF 2.15

Ill.no.	Partno.	Part	Quantity required	Info	Price
5	142534	HORN CONTACT PIN IN STEERING WHEEL, 2.6" (6.6 CM)	1	as fitted, check length	CHF 19.15
5	142534X	HORN CONTACT PIN IN STEERING WHEEL, 3.4" (8.6 CM)	1	as fitted, check length	CHF 36.35

Ill.no.	Partno.	Part	Quantity required	Info	Price
6	608462	SLIP RING HORN CONTACT INCL. PLASTIC CARRIER AND CABLE	1		CHF 61.05

Ill.no.	Partno.	Part	Quantity required	Info	Price
7	142169A	RELAY 6RA TYPE	1		CHF 47.10

Ill.no.	Partno.	Part	Quantity required	Info	Price
8	SE910201	SCREW 3/16UNF X 5/8	2		CHF 0.65

Ill.no.	Partno.	Part	Quantity required	Info	Price
9	PWZ203	WASHER, PLAIN, 3/16" ID X 3/4" OD	2		CHF 0.75

Ill.no.	Partno.	Part	Quantity required	Info	Price
10	WL700101	WASHER SPRING 3/16	2		CHF 0.65

Ill.no.	Partno.	Part	Quantity required	Info	Price
11	HN2005	NUT 10.32 UNF 3/8 AF	2		CHF 1.05

Ill.no.	Partno.	Part	Quantity required	Info	Price
12	GGE164	HORN HIGH NOTE, TWIN TERMINAL, PLASTIC	1	TR5, TR250, TR6 all models	CHF 23.75
12	BHA4515	HORN HIGH NOTE, METAL	1	TR5, TR250, TR6 all models	CHF 76.55

Ill.no.	Partno.	Part	Quantity required	Info	Price
13	GGE165	HORN LOW NOTE, TWIN TERMINAL, PLASTIC	1	TR5, TR250, TR6, all models	CHF 23.75
13	BHA4514	HORN LOW NOTE, METAL	1	TR5, TR250, TR6, all models	CHF 76.55

Ill.no.	Partno.	Part	Quantity required	Info	Price
14	57H5309	HORN MOUNTING BRACKET	2		CHF 6.50
14	GGE110	HORN BRACKET ANGLED	2		CHF 5.05

Ill.no.	Partno.	Part	Quantity required	Info	Price
14	57H5309	HORN MOUNTING BRACKET	2		CHF 6.50
14	GGE110	HORN BRACKET ANGLED	2		CHF 5.05

Ill.no.	Partno.	Part	Quantity required	Info	Price
15	SH604041	SCREW 1/4" UNF X 1/2"	4		CHF 0.55

Ill.no.	Partno.	Part	Quantity required	Info	Price
16	GHF331	WASHER SPRING 1/4"	4		CHF 0.55

Ill.no.	Partno.	Part	Quantity required	Info	Price
17	GHF300	WASHER 1/4 X 1/2 OD	4		CHF 0.25

Ill.no.	Partno.	Part	Quantity required	Info	Price
18	GHF200	NUT 1/4 UNF	4		CHF 0.65

Ill.no.	Partno.	Part	Quantity required	Info	Price
19	GGE164K	HORN KIT REPLACEMENT	1		availability request (add quantity to basket, offer follows)

Ill.no.	Partno.	Part	Quantity required	Info	Price
20	GGE165	HORN LOW NOTE, TWIN TERMINAL, PLASTIC	1	replacement type	CHF 23.75

Ill.no.	Partno.	Part	Quantity required	Info	Price
21	GGE164	HORN HIGH NOTE, TWIN TERMINAL, PLASTIC	1	replacement type	CHF 23.75

Ill.no.	Partno.	Part	Quantity required	Info	Price
22	57H5309	HORN MOUNTING BRACKET	2		CHF 6.50

Ill.no.	Partno.	Part	Quantity required	Info	Price
23	SH604041	SCREW 1/4" UNF X 1/2"	4		CHF 0.55

Ill.no.	Partno.	Part	Quantity required	Info	Price
24	GHF331	WASHER SPRING 1/4"	4		CHF 0.55

Ill.no.	Partno.	Part	Quantity required	Info	Price
25	GHF300	WASHER 1/4 X 1/2 OD	4		CHF 0.25

Ill.no.	Partno.	Part	Quantity required	Info	Price
26	GHF200	NUT 1/4 UNF	4		CHF 0.65


27		AIR HORN TWIN KIT		not available

Ill.no.	Partno.	Part	Quantity required	Info	Price

See also Category STEERING WHEELS
1	150277	HORN CONTACT WITH TRIUMPH EMBLEM	1	TR5, TR250, TR6 To CR1/CF1	CHF 71.50

See also Category STEERING WHEELS
2	159761	HORN PUSH ASSEMBLY, STEERING WHEEL, TRIUMPH WORD	1	TR6 From CR1/CF1	CHF 58.10
3	204741	CLAMP SPRING HORN CONTACT BUTTON (3-ARM)	1	TR5, TR250, TR6 To CR1/CF1	CHF 31.00
4	613766	CLIP, WOVEN DOOR SEAL	1	TR6 From CR1/CF1	CHF 2.15
5	142534	HORN CONTACT PIN IN STEERING WHEEL, 2.6" (6.6 CM)	1	as fitted, check length	CHF 19.15
5	142534X	HORN CONTACT PIN IN STEERING WHEEL, 3.4" (8.6 CM)	1	as fitted, check length	CHF 36.35
6	608462	SLIP RING HORN CONTACT INCL. PLASTIC CARRIER AND CABLE	1		CHF 61.05
7	142169A	RELAY 6RA TYPE	1		CHF 47.10
8	SE910201	SCREW 3/16UNF X 5/8	2		CHF 0.65
9	PWZ203	WASHER, PLAIN, 3/16" ID X 3/4" OD	2		CHF 0.75
10	WL700101	WASHER SPRING 3/16	2		CHF 0.65
11	HN2005	NUT 10.32 UNF 3/8 AF	2		CHF 1.05
12	GGE164	HORN HIGH NOTE, TWIN TERMINAL, PLASTIC	1	TR5, TR250, TR6 all models	CHF 23.75
12	BHA4515	HORN HIGH NOTE, METAL	1	TR5, TR250, TR6 all models	CHF 76.55
13	GGE165	HORN LOW NOTE, TWIN TERMINAL, PLASTIC	1	TR5, TR250, TR6, all models	CHF 23.75
13	BHA4514	HORN LOW NOTE, METAL	1	TR5, TR250, TR6, all models	CHF 76.55
14	57H5309	HORN MOUNTING BRACKET	2		CHF 6.50
14	GGE110	HORN BRACKET ANGLED	2		CHF 5.05
15	SH604041	SCREW 1/4" UNF X 1/2"	4		CHF 0.55
16	GHF331	WASHER SPRING 1/4"	4		CHF 0.55
17	GHF300	WASHER 1/4 X 1/2 OD	4		CHF 0.25
18	GHF200	NUT 1/4 UNF	4		CHF 0.65
19	GGE164K	HORN KIT REPLACEMENT	1		availability request (add quantity to basket, offer follows)
20	GGE165	HORN LOW NOTE, TWIN TERMINAL, PLASTIC	1	replacement type	CHF 23.75
21	GGE164	HORN HIGH NOTE, TWIN TERMINAL, PLASTIC	1	replacement type	CHF 23.75
22	57H5309	HORN MOUNTING BRACKET	2		CHF 6.50
23	SH604041	SCREW 1/4" UNF X 1/2"	4		CHF 0.55
24	GHF331	WASHER SPRING 1/4"	4		CHF 0.55
25	GHF300	WASHER 1/4 X 1/2 OD	4		CHF 0.25
26	GHF200	NUT 1/4 UNF	4		CHF 0.65

27		AIR HORN TWIN KIT		not available