PERFORMANCE

CAR IDENTIFICATION TR5 - TR6

Before ordering any parts for your TR sports car, it is essential that you have full details of the chassis number, engine number, body number, rear axle and gearbox numbers.

Number Locations

Commission/Chassis Number	The commission number on TR5-250 and early TR6 models were mounted on plates affixed to the top of the inner lefthand front wing. The plate included the commission number which could have a suffix 'L' or 'U' (1971 on) for lefthand drive models, and 'O' for overdrive. Paint & trim colour codes were also shown.
	Later TR6 models had the commission plate attached to the lefthand 'B' post, below the door shut plate.
Body Number	Two plates attached to the bulkhead were body numbers. One was fitted by the manufacturers of the body shell, the other by Triumph. These numbers are not required when ordering replacement parts.
Engine Number	The engine number was stamped onto a lip at the rear of the lefthand side of all engine blocks, just visible below the spark plug. The engine number is essential when ordering engine parts.
Gearbox Number	The gearbox number is stamped onto the casing just behind the clutch lever cross- haft box. On later US models the number was stamped above the starter motor bulge on the righthand side of the gearbox casing. Use this number when ordering gearbox parts.
Rear Axle Number	The rear axle number is located at the base of the axle housing, when viewed from beneath the car. Use this number when ordering axle parts.

TR5 Pi Models
1967	CP1	Prototype
	CP2	First production car, (built 29th August 1967)
	CP585	Last production car that year
1968	CP586	First production car, (built 1st January 1968)
	CP3101	Last production car, (built 19th September 1968)

TR250 Carburettor Models
1967	CD1-L	First production car, (built on 11th July 1967)
	CD2684 L	Last production car that year
1968	CD2685 L	First production car
	CD8594 L	Last production car, (built 19th September 1968)

TR6 Pi Models
1968	1969 model year
	CP25156	First production car, (built 28th November 1968)
	CP25158	Last production car that year
	CP25001	First car was probably a prototype
	CKD	CP25002 To CP25145 were CKD
1969	1969 model year
	CP25159	First production car, (built 2nd January 1969)
	CP26998	Last production car, (built 10th September 1968)
	1970 model year
	CP50001	First production car, (built 1st September 1969)
	CP50464	Last production car that year
	CKD	CP50002 To CP50436 believed to be CKD
1970	1970 model year
	CP50465	First production car, (built 1st January 1970)
	CP52785	Last production car that year
1971	1971 model year
	CP52786	First production car, (built 1st January 1971)
	CP54572	Last production car, (built 7th September 1971)
	CKD	CP54573 To CP54584 were CKD cars
	1972 model year
	CP75001	First production car, (built 27th September 1971)
	CP7544	Last production car that year
1972	1972 model year
	CP75455	First production car, (built 3rd January 1972)
	CP77718	Last production car, (built 21st September 1972)
	1973 model year
	CR169	First production car, (built 15th November 1972)
	CR664	Last production car that year
	CKD	CR1 to CR168 were CKD cars
1973	1973 model year
	CR665	First production car, (built on 2nd January 1973)
	CR2911	Last production car, (built 17th October 1973)
	1974 model year
	CR5049	First production car, (built 14th September 1973)
	CR5612	Last production car that year
	CKD	CR5001 To CR5048 were CKD cars
1974	1974 model year
	CR5613	First production car, (built 1st January 1974)
	CR6630	Last production car that year
1975	1974 model year
	CR6631	First production car, (built 1st January 1975)
	CR6701	Last production car, (built 7th February 1975)

TR6 Carburettor Models
1968	1969 model year
	CC25003 L	First production car, (built 19th September 1968)
	CC27383 L	Last production car that year
	CC25001 & CC25002	Not yet found in factory build records
1969	1969 model year
	CC27384 L	First production car, (built 2nd January 1969)
	CC32142 L	Last production car, (built 19th December 1969)
	1970 model year
	CC50001 L	First production car, (built 22nd November 1969)
	CC51032 L	Last production car that year
1970	1970 model year
	CC51033 L	First production car, (built 1st January 1970)
	CC60902 L	Last production car that year
1971	1971 model year
	CC60903 L	First production car, (built 1st January 1971)
	CC67893 L	Last production car, (built 20th August 1971)
	1972 model year
	CC75001 L	First production car, (built 20th August 1971)
	CC7881	Last production car that year
1972	1972 model year
	CC78813 U	First production car, (built 3rd January 1972)
	CC85737 U	Last production car, (built 5th October 1972)
	1973 model year
	CF1 U	First production car, (built 11th September 1972)
	CF 4028 U	Last production car that year
1973	1973 model year
	CF4029 U	First production car, (built 2nd January 1973)
	CF17002 U	Last production car that year
1974	1974 model year
	CF17002 U	First production car, (built 2nd January 1974)
	CF25777 U	Last production car, (built 18th September 1974)
	1975 model year
	CF27001 U	First production car, (built 22nd August 1974)
	CF29580 U	Last production car that year
1975	1975 model year
	CF29581 U	First production car, (built 2nd January 1975)
	CF39991 U	Last production car, (built 23rd August 1975)
	1976 model year
	CF50001 U	First production car, (built 29th August 1975)
	CF52314 U	Last production car that year
1976	1976 model year
	CF52315 U	First production car, (built 5th January 1976)
	CF58328 U	Last production TR6, (built 15th July 1976)

unillustrated articles

Ill.no.	Partno.	Part	Quantity required	Info	Price
NI	148960	BELL CRANK	1		CHF 50.35

Ill.no.	Partno.	Part	Quantity required	Info	Price
3	149658	VALVE EXHAUST 1.25"	5	1.25" - all CP models	CHF 16.80
3	TT1715	VALVE, EXHAUST, STAINLESS STEEL, 31.7MM	5	1.25" - reshaped and gas-flowed	CHF 77.20

Ill.no.	Partno.	Part	Quantity required	Info	Price
4	146497	EXHAUST VALVE SEAT	6		CHF 23.10

Ill.no.	Partno.	Part	Quantity required	Info	Price
5	TT1207	VALVE SPRING SET, TWIN FITMENT, UPRATED	1		CHF 82.15

Ill.no.	Partno.	Part	Quantity required	Info	Price
6	TT1217	ROCKER SHAFT, TUFTRIDED	1		CHF 95.05

Ill.no.	Partno.	Part	Quantity required	Info	Price
7	TT1218	ROCKER SPACER SET	1		CHF 79.20

Ill.no.	Partno.	Part	Quantity required	Info	Price
8	TT1246	ROLLER ROCKER KIT, HIGH LIFT, 1.65:1	1		CHF 2'277.00

Ill.no.	Partno.	Part	Quantity required	Info	Price
10	308292	EXHAUST M/FOLD-PI- NCA	1		availability request (add quantity to basket, offer follows)

Ill.no.	Partno.	Part	Quantity required	Info	Price
11	TT1200	MANIFOLD, EXHAUST, TUBULAR, MILD STEEL	1	mild steel	CHF 813.10

Ill.no.	Partno.	Part	Quantity required	Info	Price
12	BSS-TH-021	EXHAUST SYSTEM BELL, STAINLESS STEEL, TR6 SPORTS	1	stainless steel - not approved for Swiss road traffic!	CHF 707.70


13		METERING UNIT, with push on petrol return union	1	see FUEL SYSTEM - INJECTION SYSTEM

Ill.no.	Partno.	Part	Quantity required	Info	Price
14			1

Ill.no.	Partno.	Part	Quantity required	Info	Price
15	TT1256	CARBURETTOR SET, HS6 1 3/4", PAIR	1	new	CHF 1'871.00

Ill.no.	Partno.	Part	Quantity required	Info	Price
16	TT1261	LINKAGE KIT, HS6 CARBURETTOR CONVERSION	1		CHF 55.05

Ill.no.	Partno.	Part	Quantity required	Info	Price
17	148496	LINK ROD, THROTTLE, VERTICAL, SHORT	1		CHF 42.10

Ill.no.	Partno.	Part	Quantity required	Info	Price
18	TT9941	SELECTOR END	2		CHF 31.80

Ill.no.	Partno.	Part	Quantity required	Info	Price
19	218410	THROTTLE SUPPORT BRACKET	1		CHF 59.10

Ill.no.	Partno.	Part	Quantity required	Info	Price
20	TKC1338Z	USE TKC1338UR	2

Ill.no.	Partno.	Part	Quantity required	Info	Price
21	TT12561	ADAPTOR PLATE KIT	1		availability request (add quantity to basket, offer follows)

Ill.no.	Partno.	Part	Quantity required	Info	Price
22	KN56-9098	AIR FILTER, K&N, HS6, CENTRE HOLE, 83MM	2		CHF 187.00

Ill.no.	Partno.	Part	Quantity required	Info	Price
23	AUD1362	NEEDLE TW	2	HS6 fixed - TW	CHF 45.35
23	AUD1328	NEEDLE SM	2	HS6 fixed - SM	CHF 45.35
23	NZX8002	NEEDLE BDB	2	HS6 biased - BDB	CHF 48.30
23	NZX8015	NEEDLE BDQ	2	HS6 biased - BDQ	CHF 48.30
23	NZX8012	NEEDLE BDM	2	HS6 biased - BDM	CHF 49.05
23	CUD1104	NEEDLE BAE	2	HS6 biased - BAE	CHF 49.05
23	CUD1111	NEEDLE BAM	2	HS6 biased - BAM	CHF 50.65
23	ZEB16625	NEEDLE "2E", STANDARD	2	175CD fixed - 2E	CHF 48.35


24		DISTRIBUTOR, reconditioned/exchange	1	see category ELECTRICAL - IGNITION UPRATED

Ill.no.	Partno.	Part	Quantity required	Info	Price
25	TT1903	DISTRIBUTOR SPRING SET	1		CHF 51.15

Ill.no.	Partno.	Part	Quantity required	Info	Price
26	TT2981	IGNITION COIL, SPORTS, 12 VOLT, NON BALLASTED	1		CHF 60.40

Ill.no.	Partno.	Part	Quantity required	Info	Price
27	TT1272	HT LEAD SET TR5-6 COBALT	1		availability request (add quantity to basket, offer follows)

Ill.no.	Partno.	Part	Quantity required	Info	Price
28	TGK125	BOSCH TYPE FUEL PUMP KIT	1		CHF 712.80

Ill.no.	Partno.	Part	Quantity required	Info	Price

29		CRANKSHAFT, tuftrided, new	1	see INTERNAL ENGINE

Ill.no.	Partno.	Part	Quantity required	Info	Price

30		FLYWHEEL, alloy, includes ring gear	1	see INTERNAL ENGINE

Ill.no.	Partno.	Part	Quantity required	Info	Price

31		FLYWHEEL, steel, without ring gear	1	see INTERNAL ENGINE

Ill.no.	Partno.	Part	Quantity required	Info	Price

32		CLUTCH COVER ASSEMBLY	1	see CLUTCH SYSTEM

Ill.no.	Partno.	Part	Quantity required	Info	Price

33		CLUTCH DRIVEN PLATE	1	see CLUTCH SYSTEM

Ill.no.	Partno.	Part	Quantity required	Info	Price
34	142647K	BEARING SET, CAMSHAFT	1		CHF 77.20

Ill.no.	Partno.	Part	Quantity required	Info	Price

35		CAMSHAFT, new or reconditioned	1	see INTERNAL ENGINE

Ill.no.	Partno.	Part	Quantity required	Info	Price
36	TT1209	CAM FOLLOWER, TAPPET, LIGHTENED/UPRATED	12	lightened & tuftrided	availability request (add quantity to basket, offer follows)

Ill.no.	Partno.	Part	Quantity required	Info	Price
37			12	8.11", tubular - all CP models
37	TT10433	PUSH ROD, ENGINE, 8.25", TUBULAR	12	8.25", tubular - all CR models	availability request (add quantity to basket, offer follows)
37	TT1633	PUSH ROD, ENGINE, 7.99", TUBULAR	12	7.99 ", tubular - alternatives	CHF 31.10
37	148916	PUSH ROD, ENGINE 8.30, FORGED	12	8.3 ", solid - alternatives	CHF 12.80
37	149513	PUSH ROD, ENGINE, 8.11", FORGED	12	8.149 ", solid - alternatives	CHF 9.60

Ill.no.	Partno.	Part	Quantity required	Info	Price
38	TT2223S	BOLT SET, FLYWHEEL TO CRANK, UPRATED, ENGINE SET	1	uprated	CHF 87.50

Ill.no.	Partno.	Part	Quantity required	Info	Price

39		CYLINDER HEAD	1	see category CYLINDER HEAD

Ill.no.	Partno.	Part	Quantity required	Info	Price
40	TT29422	KENLOWE FAN KIT, (12")	1		availability request (add quantity to basket, offer follows)

Ill.no.	Partno.	Part	Quantity required	Info	Price
41	158417SST	WATER PIPE & ADAPTOR STAINLESS STEEL	1		CHF 106.50

Ill.no.	Partno.	Part	Quantity required	Info	Price
42	IM50250	THERMO SWITCH, 86°C ON, 76°C OFF	1		CHF 19.10

Ill.no.	Partno.	Part	Quantity required	Info	Price
43	154380	PULLEY & DAMPER ASSY	1		availability request (add quantity to basket, offer follows)

Ill.no.	Partno.	Part	Quantity required	Info	Price
44	GCB11088	FAN BELT, LENGTH 1088MM, WIDTH 10MM	1		CHF 13.20
NI	RFK12	COOLING FAN KIT, REVOTEC, SUCTION TYPE, 350MM - NEGATIVE EARTH	1		CHF 394.70

Ill.no.	Partno.	Part	Quantity required	Info	Price
3	149658	VALVE EXHAUST 1.25"	5	1.25" - all CP models	CHF 16.80
3	TT1715	VALVE, EXHAUST, STAINLESS STEEL, 31.7MM	5	1.25" - reshaped and gas-flowed	CHF 77.20
4	146497	EXHAUST VALVE SEAT	6		CHF 23.10
5	TT1207	VALVE SPRING SET, TWIN FITMENT, UPRATED	1		CHF 82.15
6	TT1217	ROCKER SHAFT, TUFTRIDED	1		CHF 95.05
7	TT1218	ROCKER SPACER SET	1		CHF 79.20
8	TT1246	ROLLER ROCKER KIT, HIGH LIFT, 1.65:1	1		CHF 2'277.00
10	308292	EXHAUST M/FOLD-PI- NCA	1		availability request (add quantity to basket, offer follows)
11	TT1200	MANIFOLD, EXHAUST, TUBULAR, MILD STEEL	1	mild steel	CHF 813.10
12	BSS-TH-021	EXHAUST SYSTEM BELL, STAINLESS STEEL, TR6 SPORTS	1	stainless steel - not approved for Swiss road traffic!	CHF 707.70

13		METERING UNIT, with push on petrol return union	1	see FUEL SYSTEM - INJECTION SYSTEM
14			1
15	TT1256	CARBURETTOR SET, HS6 1 3/4", PAIR	1	new	CHF 1'871.00
16	TT1261	LINKAGE KIT, HS6 CARBURETTOR CONVERSION	1		CHF 55.05
17	148496	LINK ROD, THROTTLE, VERTICAL, SHORT	1		CHF 42.10
18	TT9941	SELECTOR END	2		CHF 31.80
19	218410	THROTTLE SUPPORT BRACKET	1		CHF 59.10
NI	148960	BELL CRANK	1		CHF 50.35
20	TKC1338Z	USE TKC1338UR	2
21	TT12561	ADAPTOR PLATE KIT	1		availability request (add quantity to basket, offer follows)
22	KN56-9098	AIR FILTER, K&N, HS6, CENTRE HOLE, 83MM	2		CHF 187.00
23	AUD1362	NEEDLE TW	2	HS6 fixed - TW	CHF 45.35
23	AUD1328	NEEDLE SM	2	HS6 fixed - SM	CHF 45.35
23	NZX8002	NEEDLE BDB	2	HS6 biased - BDB	CHF 48.30
23	NZX8015	NEEDLE BDQ	2	HS6 biased - BDQ	CHF 48.30
23	NZX8012	NEEDLE BDM	2	HS6 biased - BDM	CHF 49.05
23	CUD1104	NEEDLE BAE	2	HS6 biased - BAE	CHF 49.05
23	CUD1111	NEEDLE BAM	2	HS6 biased - BAM	CHF 50.65
23	ZEB16625	NEEDLE "2E", STANDARD	2	175CD fixed - 2E	CHF 48.35

24		DISTRIBUTOR, reconditioned/exchange	1	see category ELECTRICAL - IGNITION UPRATED
25	TT1903	DISTRIBUTOR SPRING SET	1		CHF 51.15
26	TT2981	IGNITION COIL, SPORTS, 12 VOLT, NON BALLASTED	1		CHF 60.40
27	TT1272	HT LEAD SET TR5-6 COBALT	1		availability request (add quantity to basket, offer follows)
28	TGK125	BOSCH TYPE FUEL PUMP KIT	1		CHF 712.80

29		CRANKSHAFT, tuftrided, new	1	see INTERNAL ENGINE
34	142647K	BEARING SET, CAMSHAFT	1		CHF 77.20
36	TT1209	CAM FOLLOWER, TAPPET, LIGHTENED/UPRATED	12	lightened & tuftrided	availability request (add quantity to basket, offer follows)
37			12	8.11", tubular - all CP models
37	TT10433	PUSH ROD, ENGINE, 8.25", TUBULAR	12	8.25", tubular - all CR models	availability request (add quantity to basket, offer follows)
37	TT1633	PUSH ROD, ENGINE, 7.99", TUBULAR	12	7.99 ", tubular - alternatives	CHF 31.10
37	148916	PUSH ROD, ENGINE 8.30, FORGED	12	8.3 ", solid - alternatives	CHF 12.80
37	149513	PUSH ROD, ENGINE, 8.11", FORGED	12	8.149 ", solid - alternatives	CHF 9.60
38	TT2223S	BOLT SET, FLYWHEEL TO CRANK, UPRATED, ENGINE SET	1	uprated	CHF 87.50
40	TT29422	KENLOWE FAN KIT, (12")	1		availability request (add quantity to basket, offer follows)
41	158417SST	WATER PIPE & ADAPTOR STAINLESS STEEL	1		CHF 106.50
42	IM50250	THERMO SWITCH, 86°C ON, 76°C OFF	1		CHF 19.10
43	154380	PULLEY & DAMPER ASSY	1		availability request (add quantity to basket, offer follows)
44	GCB11088	FAN BELT, LENGTH 1088MM, WIDTH 10MM	1		CHF 13.20
NI	RFK12	COOLING FAN KIT, REVOTEC, SUCTION TYPE, 350MM - NEGATIVE EARTH	1		CHF 394.70